Pod, Stern, Shaft, Jet & V-Drive

Engine

All internal lubricated parts including: pistons, piston rings and pins, crankshaft and main bearings, rod bearings, timing chain, timing gears, rocker arms, cover, valves, valve springs, guides and seats, valve pushrods, lifters, camshaft and bearings, cylinder heads, cylinder barrels, intake manifold, exhaust manifold, flywheel and ring gear, harmonic balancer, oil pan, oil pump, engine mounts, distributor housing, shaft and bearings, oil cooler housing, oil filter housing, turbocharger housing and all internal parts, turbocharger waste gate actuator, seals and gaskets.

Diesel Engine

All parts included in the engine section including head bolts, air intake housing, flywheel housing and front covers.

Lubricating System

Oil injection pump, drive gear and/or shaft, oil tank, oil cap, oil level sensor, warning horn, oil lines, complete oil injection metering system, oil injection check valves, seals and gaskets.

Cooling System

Engine water pump (excluding outboard impellers), coolant circulating pump, heat exchangers, seals and gaskets.

Fuel System

Fuel distributors, fuel injection pump, electronic fuel injector, control unit, flame arrestor, fuel pump, carburettor body, diaphragm.

Transmission

All internally lubricated parts within the transmission case, transmission mounts, oil pan, gears, bearings, bearing carriers, clutch and thrust plates, clutch drums, shift bands, hydraulic pumps, valve bodies, seals and gaskets.

Shaft Drive / Surface Drive

All internally lubricated parts, bearings and couplings.

V-Drive

All internally lubricated parts within the V-Drive case, case, bevel gears, bearings, thrust bearings, shafts, shims and bearing carriers, seals and gaskets.

Jet-Drive

All internally lubricated parts in the pump housing, housing, seals and gaskets.

Pod and Stern Drive/Upper and Lower Units

All internally lubricated parts contained within the gear case and upper housing.

Steering

Steering control helm assembly, control rack and pinion and yoke assembly, power steering pump, hydraulic steering head, hydraulic steering lines and control valves, power cylinder assembly, steering wheel and coupling, steering cable, seals and gaskets.

Controls

Shift and throttle control cables, ignition switch, neutral start switch, throttle cam lever, Electronic Shift and Throttle controls including ECU's and Actuators.

Electrical

Alternator, stator, starter, power tilt motor, voltage regulator, regulator rectifier, engine wiring harness, engine terminal blocks, choke solenoid, starter drive, ignition coil, starter solenoid, switch box, ignition module, trigger.

Power Trim and Tilt

Spring sending unit, oil pump, pump relief valve, spring, o-ring, trim cylinder, motor, solenoids, wiring harness, manual release valve, hydraulic pump, reverse lock valve, limit switches, master switches, seals and gaskets.

Electronic Fuel Injector Coverage

Fuel injectors, electronic control modules, throttle position sensor, idle speed solenoid, detonation, knock sensor, ignition control sensor, mass air flow sensor, manifold absolute pressure sensor, crank position sensor, air temperature sensor, coolant sensor, injector wiring harness, fuel injection lines and fittings, all electronic injection sensors and controls.